Product ID:MAGMA CR1 BASE - RED/GRAY PART A, 3206/1283
MSDS Date:08/14/1991
FSC:8030
NIIN:00N035692
Kit Part:Y
MSDS Number: BQLFG

Emergency Phone: 305-594-4994;305-274-6512

Info Phone: 305-594-4994

Preparer: J. PARTINGTON

Cage: 0PX05

Telephone: 305-594-4994

Cage: 0PX05

EPOXY PHENOL NOVALAC RESIN

CAS: 28064-14-4

Fraction By Weight: 15-40%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NO Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:SKIN SENSITIZER & SKIN IRRITATION.
ACUTE: SKIN AND EYE IRRITATION. CHRONIC: IRRITATION, SENSITIZATION,
AND DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:NONE SPECIFIED BY MANUFACTURER.
Medical Cond Aggravated by Exposure:SKIN AND EYE CONDITIONS.

First Aid:INHAL:IF SYMPS ARE EXPERIENCED, REMOVE SOURCE OF CONTAM &/OR
MOVE VICTIM TO FRESH AIR. IF RECOVERY IS DELAYED OR THERE ARE SIGNS
OF DISTRESS OBTAIN MED ATTN IMMED. EYE:FLUSH EYES W/WATER FOR AT
LEAST 15 MIN. SEEK ADVICE IF ANY IRRIT PERSISTS. SKIN:IMMED REMOVE
EXCESS W/A CLEAN CLOTH & WASH THORO W/SOAP & WATER. IF
IRRIT/INFLAMM PERSISTS, SEEK MED ADVICE. INGEST:DO NOT INDUCE
VOMIT. (SUPP DATA)

Flash Point Method:SCC
Flash Point:>212F,>100C
Extinguishing Media:WATER FOG (NOT A DIRECT STREAM OF WATER), FOAM,
CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL PROT
EQUIP . FULL BUNKER GEAR SHOULD BE WORN IN EXTREME AREAS. USE SAND
TO CONTAIN BURNING MATERIAL.
Unusual Fire/Explosion Hazard:DECOMPOSITION AND COMBUSTION PRODUCTS MAY
BE HAZARDOUS.

Spill Release Procedures:ABSORB WITH AN INERT MATERIAL (E.G. EARTH OR
SAND). SWEEP UP, PLACE INTO SUITABLE LABELLED CONTAINERS, SEAL AND
DISPOSE OF PROPERLY. FLUSH AREA WITH DETERGENT AND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:AVOID CONTACT WITH SKIN AND EYES.
OVERHEATING MAY CAUSE CONTAINERS TO RUPTURE. CONTAINER SHOULD BE
STORED UNDER COOL, DRY CONDITIONS.
Other Precautions:EMPTY CNTNRS WILL RETAIN RESIDUE AND MAY BE
DANGEROUS. CHECK ALL CONTAINERS FOR LEAKS AT REGULAR INTERVALS AND
BEFORE USE.

Respiratory Protection:IN CONFINED AREAS OR WHERE GOOD
NATURAL/MECHANICAL VENT IS NOT AVAILABLE AN APPROPRIATE NIOSH/MSHA
APPROVED RESPIRATOR SHOULD BE WORN. WHERE MACHINING/ABRADING OF
CURED MATL LEADS TO PRODUCTION OF RES P AND/OR NUISANCE DUST, AN
(SUPP DATA)
Ventilation:WHERE ADEQUATE NATURAL VENTILATION IS NOT AVAILABLE PROVIDE
SUITABLE LOCAL EXHAUST VENTILATION.
Protective Gloves:IMPERVIOUS GLOVES (NEOPRENE/PVC).
Eye Protection:CHEMICAL WORKERS GOGGLES
Other Protective Equipment:EYEWASH STATION. SFTY BOOTS SHLD BE WORN &
CLEANED THOROUGHLY BEFORE REUSE. SUITABLE PROT CLTHG TO MINIMIZE
SKIN CNTCT.
Work Hygienic Practices:WHEN USING, DO NOT EAT, DRINK/SMOKE. REMOVE
CONTAM CLTHG & LAUNDER BEFORE REUSE. WASH HANDS W/SOAP & WATER
(SUPP DATA)
Supplemental Safety and Health
FIRST AID PROC: RINSE MOUTH WITH WATER AND DRINK PLENTY OF WATER. CALL
TAMPA BAY REGIONAL POISON CTR (TEL.NO 1-800-282-3171) AND/OR SEEK
MEDICAL ADVICE. HYGIENE PRACT: AFTER HANDLING THIS PRODUCT AND USE
HAND CREAM. RESP PROT: APPROPRIATE NIOSH/MSHA APPROVED RESP SHOULD
BE WORN.

HCC:N1
Boiling Pt:B.P. Text:DECOMPOSES
Spec Gravity:1.35
Solubility in Water:NEGLIGIBLE <0.1%
Appearance and Odor:RED OR GRAY PASTE WITH EPOXY ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS, BASES, AND AMINES.
Hazardous Decomposition Products:GASEOUS COMBINATIONS OF CARBON,
HYDROGEN AND OXYGEN MAY OCCUR AT ELEVATED TEMPERATURES.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.